Boeing’s ‘single point failure': Why was there no backup system on 737 Max jet? – USA TODAY
Boeing Company CEO Dennis Muilenburg is apologizing after two deadly 737 MAX plane crashes. Muilenburg says Boeing has teams of experts “working tirelessly” to prevent anymore accidents.
When it comes to safety, modern commercial aircraft are known not only for having back-up systems, but in some cases, back-ups of their back-ups.
So even as Boeing has taken responsibility for a fatal flaw in a key anti-stalling system in its 737 Max 8, mystery still surrounds why the software was designed toÂ beÂ dependent on a single outside sensor, though it was equipped with two, triggering a chain of events that led to the crashes of Lion Air and Ethiopian Airlines jetliners less than five months apart.
Boeing “violated a basic principle of aircraft design by allowing a single point failure to trigger a sequence of events that could result in a loss of control,” said Brian Alexander, an attorney for a law firmÂ specializing in aviation accidents, Kreindler & Kreindler in New York, thatÂ is contemplating lawsuits on behalf of victims’ families in the Ethiopian Airlines crash.
Based on an initial report from crash investigators, Boeing CEO Dennis Muilenburg acknowledged Thursday that erroneous data sent to the system led to the Lion Air crash off Indonesia in October that killed 189 passengers and crew and the Ethiopian Airlines disaster in Africa that took 157 lives on March 10, both in the 737 Max 8. He vowed Boeing would fix the problem.
Others, however, aren’t so sure that Boeing can find an adequate repair, saying that the twin crashes are proof that the plane’s problems run deeper than flawed sensors. They say the design itself has created inherent problems that simple fixes won’t solve.
“You go to the source of the problem, not the symptom,” said consumer advocate Ralph Nader, who lost a niece in the Ethiopian Airlines crash. “An aircraft hasÂ to be designed stall proof, not stall prone.”
For now, all Boeing 737 Max 8 and 9 aircraft around the world have beenÂ grounded amid investigations into the source of the problem. Boeing, on the basis of probes into the two crashes, has focused on the Maneuvering Characteristics Augmentation System, or MCAS.
The system is supposed to automatically push down the plane’s nose whenÂ eitherÂ of two angle-of-attack sensors, one mounted on each side of the fuselage, detects that the plane had pointed upward so steeply that it can stall. MCAS was added because of the possibility the nose can pitch up due to the larger, heavier engines that were added to the Max.
But in an unusual move, engineers designed MCAS to initiate when it detected too steep of an ascent from either sensor. TheÂ sensors didn’t work in tandem.
In a statement to USA TODAY, A Boeing spokesman said the commercial aircraft giant followed established industry “assumptions and processes” in creating the fight control systems.
“Single sources of data are considered acceptable in such cases by our industry and additional changes to the system were not deemed warranted,” spokesman Peter Pedraza said.
The company felt safe in adding MCAS because if there was a malfunction, “a pilot would be able to counteract erroneous system input” utilizing either of two methods,Â Pedraza said.
One way would be to use switches on the control wheel to adjust the plane’s trim, which adjusts control surfaces to make the plane easier to fly like cruise control in a car. Or the same task can be done manually. Either way, the goal would have been to control the angle of the aircraft.Â
Yet apparently, those procedures didn’t work for the Lion Air andÂ Ethiopian Airlines crews. In the case of Ethiopian, which encountered problems soon after takeoff from Addis Ababa, pilots tried Boeing’s procedures for an MCAS malfunction repeatedly and still couldn’t control the plane, Ethiopian Minister of Transport Dagmawit Moges said Thursday.
The single source of data seems unusual given the lengths that Boeing has gone to build redundancies into its jetliners.
For the 777, Boeing’s twin-aisle intercontinental jet, engineers created triple redundancy for its computers, hydraulics, communications and electrical power. Perhaps the best illustration of the lengths that the company was willing to go on back-ups was found inÂ the plane’s primary flight computer. It was built withÂ three microprocessors, instead of one, and each of them came from a different manufacturer:Â Intel, AMD and Motorola, according to an account by a Boeing engineer.
The decision on how many backups to haveÂ isn’t easy, said Peter Seiler,Â an associate professor of aerospace engineering at the University of Minnesota who used to work at Boeing. It depends on how critical to safety the system is deemed, how much it will distract an already-busy flight crew if it fails and the odds of it failing, among other factors.
“I spent four years working on the 787 and I spent all my time thinking about every possible way things can go wrong,” he said.
It may be that Boeing didn’t deem MCAS to be critical enough to warrant a backup. It was designed, after all, as part of an overall goal of makingÂ MaxÂ jets fly and feel like the previous 737 version, the Next Generation or NG, and the ones before it.
“If the MCAS fails, the crew loses a little bit of stall protection, but stall protection is primarily the responsibility of the crew,” said Clint Balog, a 42-year pilot who is an associate professor at Embry-Riddle Aeronautical University.Â
With the 737 update,Â BoeingÂ saved time by not having to createÂ an all-new jet. It alsoÂ could sell the 737 to airlines on the basis that because Max was just an update, pilot training costs would be limited.
Boeing’s proposed fix of the problem to the FAA involves requiring that MCAS constantly monitor readings from the two sensors and disengage if they differ widely from each other, and to make standard a cockpit warning light that was previously an option.
“Whenever there is an accident or incident, our industry has a history of going back and challenging the basic assumptions, and when appropriate, making changes,” Boeing spokesman Pedraza said. “This process has led to over 50 years of continuous safety improvement.”